stone dust in concrete effect on compressive strength

Stone Dust in Concrete: Effect on Compressive Strength

found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.

get price

Stone Dust in Concrete : Effect on Compressive Strength ...

115 erpublication AbstractStone dust is a waste material obtained from crusher plants. It has potential to be used as partial replacement of natural river sand in concrete. Use of stone dust in concrete not only improve the quality of concrete but also conserve the natural river sand for future generations. In the present investigation, an experimental program was carried out to study ...

get price

EFFECT OF STONE DUST ON COMPRESSIVE STRENGTH OF

Mix Design The design mix proportion of 1:1.65:3 at W/C ratio of 0.50 were used for M25 grade of concrete and the cement content was 380 kg/m3, satisfying the requirements of IS-10262-2009. RESULTS AND DISCUSSION 1. The compressive strength of concrete made using stone dust at different proportion is shown in table 6. 2.

get price

Effect of Stone Dust on Strength of Concrete

some relevant studies regarding the effect of stone dust on mechanical property like compressive strength. Hence in this paper strength and properties of conventional concrete and stone dust concrete are compared so that it will be helpful to other researchers. Key words: Compressive Strength, Concrete, Natural Sand, Mechanical Properties ...

get price

EFFECT OF STONE DUST ON COMPRESSIVE STRENGTH OF

The compressive strength of specimens (100mm cubes) cast for different proportions of stone dust was determined and compare the same with referral concrete. The result showed that the stone dust can effectively been used as partial replacement of natural fine aggregate without compromising the compressive strength.

get price

Effect of stone dust on strength of concrete: A Review

compressive strength, split tensile strength, flexural strength, acid resistance property, water absorption characteristic, porosity and sorptivity through their experiments. Different samples of conventional concrete and stone dust concrete were prepared and tested. It was

get price

Influence of stone dust as fine aggregate replacement on ...

the effect of mix proportioning and stone dust replacement levels in compressive strength of concretes, whose results were analyzed through an Analysis of Variance (ANOVA), to verify the statistical significance of controlled parameters in response to the experiment. Materials and methods

get price

Utilization of Stone Dust as Fine Aggregate Replacement in ...

of fine aggregate with stone dust. The results shows strength of concrete increases within 5-12 percent up to 50 percent replacement of fine aggregate. And at 60 percent stone dust in concrete the maximum value of compressive strength is obtained which is 17 percent more than referral concrete (concrete with zero percent stone dust).

get price

An Experimental Investigation on Stone Dust as Partial ...

possibility use of stone dust in concrete, as partial replacement of fine aggregate. An experimental program was conducted to determine the effect of stone dust on compressive and flexural strength of concrete. The replacement level of fine aggregate varied between 30-70% at an interval of 10%. Materials and methods

get price

What are the advantages and disadvantages of stone dust in ...

Stone dust - if you are talking about the finer particles than 150 micron - it is not recommended to use in concrete. Almost everywhere, concrete is done using crush stone sand. Cement is normally passing through 90 micron. Dust have particles fin...

get price

Effect of stone dust on strength of concrete: A Review

compressive strength, split tensile strength, flexural strength, acid resistance property, water absorption characteristic, porosity and sorptivity through their experiments. Different samples of conventional concrete and stone dust concrete were prepared and tested. It was

get price

EFFECT OF STONE DUST ON COMPRESSIVE STRENGTH OF CONCRETE

The compressive strength of specimens (100mm cubes) cast for different proportions of stone dust was determined and compare the same with referral concrete. The result showed that the stone dust can effectively been used as partial replacement of natural fine aggregate without compromising the compressive strength.

get price

Influence of stone dust as fine aggregate replacement on ...

Dec 29, 2017  The use of stone dust in concrete provides environmental benefits by reducing the impacts produced by the extraction of natural sand. The use of this material can also offer economic advantages, since the product is less costly than natural sand. In this way, the present work evaluated the compressive strength of concretes made with stone dust in different replacement levels (30% and

get price

Influence of stone dust as fine aggregate replacement on ...

the effect of mix proportioning and stone dust replacement levels in compressive strength of concretes, whose results were analyzed through an Analysis of Variance (ANOVA), to verify the statistical significance of controlled parameters in response to the experiment. Materials and methods

get price

An Experimental Investigation on Stone Dust as Partial ...

possibility use of stone dust in concrete, as partial replacement of fine aggregate. An experimental program was conducted to determine the effect of stone dust on compressive and flexural strength of concrete. The replacement level of fine aggregate varied between 30-70% at an interval of 10%. Materials and methods

get price

Effect of Limestone Dust Concrete Construction Magazine

Apr 01, 1972  A publication titled Stone Sand by J. E. Gray and J. E. Bell, National Crushed Stone Association, Engineering Bulletin No. 13, 1964 discusses the effect of dust on the properties of concrete. Basically, dust affects the bond between the cement and aggregate so that compressive strength can be considerably reduced, and the dust material ...

get price

Sustainable Construction—Use of Stone Dust as Plasticiser ...

5.2. Compressive Strength Compressive strength tests on cubes at 7, 28 and 42 days showed that the rate of development of strength of SCC with blended cement and containing 10% and 20% sand replacement with stone dust is similar to that for control specimen. The compressive strengths of SCC with blended cement and containing 10% and

get price

INVESTIGATION ON STONE DUST AND VITRIFIED SCRAP AS ...

Compressive strength 54.28N/mm2 FINE AGGREGATE a) Sand: River sand was used as fine aggregate. The specific gravity of sand was 2.65 and fineness modulus of fineness was 2.54 b) Stone dust: Stone dust used in the laboratory investigations was procured from a local crushing plant.

get price

Replacement of stone Dust and Ceramic scrap as Aggregate ...

The compressive strength of 05% stone dust and ceramic waste sample is in close proximity of the referral concrete. Thus, it can be concluded that stone dust up to 05% with 05% ceramic waste aggregate is satisfactory for use. Results show that with partial replacement of stone dust with 05% and 05% Ceramic waste coarse

get price

What are the advantages and disadvantages of stone dust in ...

Stone dust - if you are talking about the finer particles than 150 micron - it is not recommended to use in concrete. Almost everywhere, concrete is done using crush stone sand. Cement is normally passing through 90 micron. Dust have particles fin...

get price

(PDF) The Utilization Of Crushed Stone Dust As A ...

Experimental Investigation Characteristics Stone dust obtained from granite stone Test quarry was used as the fine aggregate. Compared to Size of cubes 150 x 150 x 150mm were sand, stone dust was finer with relatively lower tested to determine the compressive strength, three fineness modulus.

get price

Stone crusher dust as a fine aggregate in Concrete for ...

Ilangovana et al., 2008 reported strength of quarry rock dust concrete was comparably 10-12 % more than that of similar mix of conventional concrete. Hameed and Sekar, 2009 studied effect of crushed stone dust as fine sand and found the flexural strength increases than the concrete with natural sand but the values decreases as

get price

Effect of Dust Contain In Artificial Sand on Compressive ...

replacing 60% of fine aggregate with stone dust concrete of maximum compressive strength can be made as compared to all other replacement levels. 3. Experimental Investigation 3.1Materials: To check the impact of dust contain we have tested m20 grade concrete with different samples of sand available in

get price

The effect of using granite dust as a component of ...

Dec 01, 2020  Granite dust has a positive effect on the early strength of concrete, as well as the strength after 90 and 180 days of hardening of samples. Download : Download high-res image (543KB) Download : Download full-size image; Fig. 4. Microstructure of concrete without granite dust (a) and with granite dust (b) at age of 28 days.

get price

IJESRT

1. The compressive strength of concrete made using stone dust at different proportion is shown in table 6. 2. The same results are presented in fig.1 for visual observation Table 4. Compressive Strength of Different Mixes 6 150 µ - - - - 0-10 7 Pan - - - - 0 Total Cumulative % Retained = 243.8

get price

Influence of stone dust as fine aggregate replacement on ...

Dec 29, 2017  The use of stone dust in concrete provides environmental benefits by reducing the impacts produced by the extraction of natural sand. The use of this material can also offer economic advantages, since the product is less costly than natural sand. In this way, the present work evaluated the compressive strength of concretes made with stone dust in different replacement levels (30% and

get price

Compressive and Flexural Strengths of Concrete using Stone ...

compressive strength of concrete increased by 10.05% at the age of 28 d compared to referral concrete. It can be seen that compressive strength is increased with addition of stone dust, but only at 60% further addition of stone dust resulted in decrease of the strength that is similar to the finding of kujur et al. (2014) and reported

get price

Effect of Dust Contain In Artificial Sand on Compressive ...

replacing 60% of fine aggregate with stone dust concrete of maximum compressive strength can be made as compared to all other replacement levels. 3. Experimental Investigation 3.1Materials: To check the impact of dust contain we have tested m20 grade concrete with different samples of sand available in

get price

An Experimental Investigation on Stone Dust as Partial ...

possibility use of stone dust in concrete, as partial replacement of fine aggregate. An experimental program was conducted to determine the effect of stone dust on compressive and flexural strength of concrete. The replacement level of fine aggregate varied between 30-70% at an interval of 10%. Materials and methods

get price

Use of Stone Dust in the Design of High Performance Concrete

Compressive strength, slump, ... Kiliswa (2012), [6] studied the effect of quarry dust on the strengths and permeability of concrete (Class 20 and 25). From his results he concluded that concrete designed with quarry dust as a substitute of river sand had ... Batching was done by mass for cement and stone dust (American Concrete Institute, 1997 ...

get price

Seven Days Compressive Strength of Cellular Lightweight ...

foam, thus the decrease in the compressive strength of the concrete. The foamed lightweight concrete is not suitable to be used as non-load bearing wall as the compressive strength is 27% less than recommended. Nevertheless the compressive strength is accepted to be produced as non-load bearing structure. B. P. S. Bhandari [3]

get price

INVESTIGATION ON STONE DUST AND VITRIFIED SCRAP AS ...

Compressive strength 54.28N/mm2 FINE AGGREGATE a) Sand: River sand was used as fine aggregate. The specific gravity of sand was 2.65 and fineness modulus of fineness was 2.54 b) Stone dust: Stone dust used in the laboratory investigations was procured from a local crushing plant.

get price

Sustainable Construction—Use of Stone Dust as Plasticiser ...

5.2. Compressive Strength Compressive strength tests on cubes at 7, 28 and 42 days showed that the rate of development of strength of SCC with blended cement and containing 10% and 20% sand replacement with stone dust is similar to that for control specimen. The compressive strengths of SCC with blended cement and containing 10% and

get price

What are the advantages and disadvantages of stone dust in ...

Stone dust - if you are talking about the finer particles than 150 micron - it is not recommended to use in concrete. Almost everywhere, concrete is done using crush stone sand. Cement is normally passing through 90 micron. Dust have particles fin...

get price

INVESTIGATION OF MECHANICAL BEHAVIOUR OF CONCRETE

SD. On the other hand, static elastic modulus and flexural strength were increased by 44% and 3.50% for the same mix proportions (10%). Also, drying shrinkage decreased by 53% when cement was replaced by 10% of CSA SD. Keywords: Coconut shell ash, stone dust, concrete, compressive strength, flexural strength. 1. INTRODUCTION

get price

Experimental Study on Concrete and Cement Plaster Using ...

The test result indicates that crushed stone dust waste can be used effectively used to replace natural sand in concrete. In the experimental study of strength characteristics of concrete using crushed stone dust as fine aggregate it is found that there is increase in compressive strength , flexural strength and tensile strength of concrete. II.

get price

Compressive Strength Of Stone - riedel-zeller

Stone Dust In Concrete: Effect On Compressive Strength 2017-8-24 on compressive strength. Results showed that by replacing 60% of fine aggregate with stone dust concrete of maximum compressive strength can be made as compared to all other replacement levels.

get price

Effects of Manufactured Sands and Blended Aggregates on ...

1. the effects of stone dust or fines in portland cement concrete, 2. the determination of the angularity and particle shape of sands, and 3. the effects of angular sands in portland cement concrete and mortar. Published studies are is almost exclusively related to the effects of manufactured sands on water demand and strength.

get price